| Capacities / Air conditioning |
Plug location |
|
High-pressure connecting pipe (H); low-pressure connecting pipe (L) |  |
| Capacities / Automatic transmission |
Gearbox refill |
10.0 (l) |
| |
| Capacities / Automatic transmission |
Plug location |
|
1 - Drain plug; 2 - Overflow plug |  |
| Electrical / Battery capacity |
Cold cranking amperes (CCA) |
720 (A) |
| |
| Electrical / Battery location |
Engine compartment |
|
| |
| Torque settings / Big-end bearing cap |
Stage 1 |
29 (Nm) |
| |
| Torque settings / Big-end bearing cap |
Stage 2 |
|
Loosen to 0 Nm | |
| Torque settings / Big-end bearing cap |
Stage 3 |
25 (Nm) |
| |
| Torque settings / Big-end bearing cap |
Stage 4 |
90 (°) |
| |
| Torque settings / Brake hose to caliper |
Renew the seal |
|
| |
| Torque settings / Brake hose to caliper |
Renew the seal |
|
| |
| Brakes / Brakes |
Brakes : General data |
|
| |
| Brakes / Brakes |
Brake pedal free travel |
3.0 - 11.0 (mm) |
| |
| Brakes / Brakes |
Brake pedal height |
171.0 - 181.0 (mm) |
| |
| Brakes / Brakes |
Front disc brakes |
|
| |
| Brakes / Brakes |
Disc diameter, front |
320.0 (mm) |
2-piston caliper | |
| Brakes / Brakes |
Disc diameter, front |
355.0 (mm) |
4-piston caliper | |
| Brakes / Brakes |
Disc thickness, front |
34.0 (mm) |
2-piston caliper | |
| Brakes / Brakes |
Disc thickness, front |
32.0 (mm) |
4-piston caliper | |
| Brakes / Brakes |
Disc thickness, front, minimum |
32.0 (mm) |
2-piston caliper | |
| Brakes / Brakes |
Disc thickness, front, minimum |
30.0 (mm) |
4-piston caliper | |
| Brakes / Brakes |
Brake pad thickness, front |
11.0 (mm) |
| |
| Brakes / Brakes |
Brake pad thickness, front, minimum |
2.0 (mm) |
| |
| Brakes / Brakes |
Disc run-out, maximum |
0.035 (mm) |
| |
| Brakes / Brakes |
Rear disc brakes |
|
| |
| Brakes / Brakes |
Disc diameter, rear |
308.0 (mm) |
1-piston caliper | |
| Brakes / Brakes |
Disc diameter, rear |
350.0 (mm) |
2-piston caliper | |
| Brakes / Brakes |
Disc thickness, rear |
16.0 (mm) |
1-piston caliper | |
| Brakes / Brakes |
Disc thickness, rear |
20.0 (mm) |
2-piston caliper | |
| Brakes / Brakes |
Disc thickness, rear, minimum |
14.0 (mm) |
1-piston caliper | |
| Brakes / Brakes |
Disc thickness, rear, minimum |
18.0 (mm) |
2-piston caliper | |
| Brakes / Brakes |
Brake pad thickness, rear |
8.5 (mm) |
| |
| Brakes / Brakes |
Brake pad thickness, rear, minimum |
2.0 (mm) |
| |
| Brakes / Brakes |
Disc run-out, maximum |
0.055 (mm) |
| |
| Steering and wheel alignment / Camber, front |
Maximum difference between the left-hand side and right-hand side |
0°33' (°) |
| |
| Torque settings / Camshaft bearing caps |
Apply sealant |
|
| |
| Torque settings / Camshaft bearing caps |
Stage 1 |
2 (Nm) |
| |
| Torque settings / Camshaft bearing caps |
Stage 2 |
6 (Nm) |
| |
| Torque settings / Camshaft bearing caps |
Stage 3 |
11 (Nm) |
| |
| Capacities / Capacities |
Engine |
|
| |
| Capacities / Capacities |
Engine sump, including filter |
6.1 (l) |
| |
| Capacities / Capacities |
Engine sump, including filter |
7.2 (l) |
Dry engine, after overhaul | |
| Capacities / Capacities |
Cooling system |
11.0 (l) |
| |
| Capacities / Capacities |
Brakes : General data |
|
| |
| Capacities / Capacities |
Brake system |
1.0 (l) |
| |
| Capacities / Capacities |
NISSAN, Automatic transmission, RE7R01A, Number of gears 7-speed |
|
| |
| Capacities / Capacities |
ETX13C |
|
| |
| Capacities / Capacities |
Transfer box |
1.0 (l) |
| |
| Capacities / Capacities |
Transfer box drain plug |
|
|  |
| Capacities / Capacities |
Transfer box filler plug |
|
|  |
| Capacities / Capacities |
Front differential, F160A |
|
| |
| Capacities / Capacities |
Air conditioning |
|
| |
| Capacities / Capacities |
Refrigerant |
550 (g) |
| |
| Capacities / Capacities |
Air-conditioning compressor oil, system total |
150 (ml) |
| |
| Steering and wheel alignment / Castor, front |
Maximum difference between the left-hand side and right-hand side |
0°39' (°) |
| |
| Engine (specifications) / Compression pressure |
Normal pressure |
16.67 (bar) |
| |
| Engine (specifications) / Compression pressure |
Minimum pressure |
14.22 (bar) |
| |
| Engine (specifications) / Compression pressure |
Differential limit between cylinders |
0.98 (bar) |
Maximum | |
| Torque settings / Coolant pump |
Renew the gasket |
|
| |
| Cooling system / Cooling system |
Engine |
|
| |
| Cooling system / Cooling system |
Cap pressure |
1.57 (bar) |
| |
| Cooling system / Cooling system |
Thermostat opening temperature |
82 (°C) |
| |
| Cooling system / Cooling system |
Thermostat fully open |
95 (°C) |
| |
| Torque settings / Crankshaft pulley |
Stage 1 |
157 (Nm) |
| |
| Torque settings / Crankshaft pulley |
Stage 2 |
90 (°) |
| |
| Torque settings / Cylinder head |
Renew the gasket |
|
| |
| Torque settings / Cylinder head |
Stage 1 |
40 (Nm) |
| |
| Torque settings / Cylinder head |
Stage 2 |
75 (°) |
| |
| Torque settings / Cylinder head |
Stage 3 |
|
Loosen to 0 Nm | |
| Torque settings / Cylinder head |
Stage 4 |
40 (Nm) |
| |
| Torque settings / Cylinder head |
Stage 5 |
90 (°) |
| |
| Torque settings / Cylinder head |
Stage 6 |
90 (°) |
| |
| Capacities / Differential |
Differential refill |
0.65 (l) |
| |
| Capacities / Differential |
Plug location |
|
1 - Drain plug; 2 - Filler plug |  |
| Engine (general) / Distribution type |
Timing chain |
|
| |
| Electrical / Electrical |
Electrical system |
|
| |
| Electrical / Electrical |
Alternator |
150 (A) |
Mitsubishi | |
| Engine (general) / Engine (general) |
Engine |
|
| |
| Engine (general) / Engine (general) |
Engine code |
VK56VD |
| |
| Engine (general) / Engine (general) |
Capacity |
5552 (cc) |
| |
| Engine (general) / Engine (general) |
Number of cylinders |
8 |
| |
| Engine (general) / Engine (general) |
Valves per cylinder |
4 |
| |
| Engine (specifications) / Engine (specifications) |
Engine |
|
| |
| Engine (specifications) / Engine (specifications) |
Firing order |
1 - 8 - 7 - 3 - 6 - 5 - 4 - 2 |
| |
| Engine (specifications) / Engine (specifications) |
Spark plugs (make and type) |
NGK DILKAR7B11 |
| |
| Engine (specifications) / Engine (specifications) |
Spark plug gap |
1.25 (mm) |
| |
| Engine (specifications) / Engine (specifications) |
Number of spark plugs |
8 |
| |
| Engine (specifications) / Engine (specifications) |
Oil pressure |
> 0.98/600 (bar/rpm) |
Engine oil temperature at least 80 °C | |
| Engine (specifications) / Engine (specifications) |
Oil pressure |
> 2.94/2000 (bar/rpm) |
Engine oil temperature at least 80 °C | |
| Engine (specifications) / Engine (specifications) |
Maximum cylinder head distortion |
0.1 (mm) |
| |
| Engine (specifications) / Engine (specifications) |
Drive belt layout |
|
|  |
| Torque settings / Engine oil drain plug |
Renew the seal |
|
| |
| Torque settings / Exhaust manifold |
Renew the gasket |
|
| |
| Torque settings / Exhaust manifold |
Renew the gasket |
|
| |
| Torque settings / Exhaust manifold |
Renew the nuts |
|
| |
| Torque settings / Fuel rail |
Stage 1 |
10 (Nm) |
| |
| Torque settings / Fuel rail |
Stage 2 |
21 (°) |
| |
| Torque settings / Inlet manifold |
Renew the gasket |
|
| |
| Torque settings / Main bearing cap |
Stage 1 |
|
Pre-tighten the bolts until full surface contact is made | |
| Torque settings / Main bearing cap |
Stage 2 |
54 (Nm) |
Bolts 1 - 10 | |
| Torque settings / Main bearing cap |
Stage 3 |
20 (Nm) |
Bolts 11 - 20 | |
| Torque settings / Main bearing cap |
Stage 4 |
90 (°) |
Bolts 1 - 10 | |
| Torque settings / Main bearing cap |
Stage 5 |
90 (°) |
Bolts 11 - 20 | |
| Torque settings / Main bearing cap |
Stage 6 |
49 (Nm) |
Bolts 21 - 30 | |
| Torque settings / Rear drive shaft to wheel bearing housing |
|
|
Clean the contact surfaces; apply grease to the area shown |  |
| Torque settings / Rear drive shaft to wheel bearing housing |
|
|
Caution! Do not use power tools when tightening the nuts or bolts | |
| Torque settings / Rear drive shaft to wheel bearing housing |
Renew the nut |
|
| |
| Wheels and tyres / Spare tyre size |
Spare tyre pressure |
4.2 (bar) |
| |
| Wheels and tyres / Spare tyre size |
Rim size |
4.0Tx18 |
| |
| Wheels and tyres / Spare tyre size |
Spare tyre pressure |
4.2 (bar) |
| |
| Wheels and tyres / Spare tyre size |
Rim size |
4.0Tx18 |
| |
| Steering and wheel alignment / Steering and wheel alignment |
Suspension |
|
| |
| Steering and wheel alignment / Steering and wheel alignment |
Equipment code: Refer to the identification label |
|
| |
| Steering and wheel alignment / Steering and wheel alignment |
Vehicle condition |
|
Unloaded |  |
| Steering and wheel alignment / Steering and wheel alignment |
Ride height |
|
|  |
| Steering and wheel alignment / Steering and wheel alignment |
Ride height, front |
762 (mm) |
18-inch wheels | |
| Steering and wheel alignment / Steering and wheel alignment |
Ride height, front |
764 (mm) |
20-inch wheels | |
| Steering and wheel alignment / Steering and wheel alignment |
Ride height, rear |
757 (mm) |
18-inch wheels | |
| Steering and wheel alignment / Steering and wheel alignment |
Ride height, rear |
758 (mm) |
20-inch wheels | |
| Steering and wheel alignment / Steering and wheel alignment |
Toe-in, front |
0°02' ± 0°02' (°) |
| |
| Steering and wheel alignment / Steering and wheel alignment |
King pin inclination (KPI), front |
7°05' ± 0°45' (°) |
| |
| Steering and wheel alignment / Steering and wheel alignment |
Toe-in, rear |
0°07' ± 0°07' (°) |
| |
| Steering and wheel alignment / Steering and wheel alignment |
Camber, rear |
-0°30' ± 0°30' (°) |
| |
| Torque settings / Sump |
Apply sealant |
|
| |
| Torque settings / Sump |
|
|
Engine side | |
| Torque settings / Sump |
Apply sealant |
|
| |
| Torque settings / Sump |
|
|
Gearbox side | |
| Torque settings / Sump |
Apply sealant |
|
| |
| Wheels and tyres / This vehicle is fitted with direct TPMS |
Note: Do not damage the tyre pressure sensors in the wheels |
|
| |
| Torque settings / Timing cover |
|
|
Left-hand side | |
| Torque settings / Timing cover |
Apply sealant |
|
| |
| Torque settings / Timing cover |
|
|
Right-hand side | |
| Torque settings / Timing cover |
Apply sealant |
|
| |
| Torque settings / Timing cover |
Apply sealant |
|
| |
| Torque settings / Torque settings |
Engine |
|
| |
| Torque settings / Torque settings |
Note: Always renew stretch bolts and self-locking nuts |
|
| |
| Torque settings / Torque settings |
Valve cover |
9 (Nm) |
Renew the gasket |  |
| Torque settings / Torque settings |
Spark plugs |
20 (Nm) |
| |
| Torque settings / Torque settings |
Oil filter |
18 (Nm) |
| |
| Torque settings / Torque settings |
Oxygen sensor |
50 (Nm) |
| |
| Torque settings / Torque settings |
Starter motor |
47 (Nm) |
| |
| Torque settings / Torque settings |
Alternator |
55 (Nm) |
| |
| Torque settings / Torque settings |
Camshaft gearwheel |
103 (Nm) |
Threads and contact surface lightly oiled | |
| Torque settings / Torque settings |
Camshaft position sensor |
7 (Nm) |
Renew the seal | |
| Torque settings / Torque settings |
Ancillary drive belt tensioner |
30 (Nm) |
| |
| Torque settings / Torque settings |
Ancillary drive belt tensioner |
22 (Nm) |
| |
| Torque settings / Torque settings |
Ancillary drive belt idler pulley |
45 (Nm) |
| |
| Torque settings / Torque settings |
Timing chain tensioner |
7 (Nm) |
| |
| Torque settings / Torque settings |
Timing chain tensioner rail |
17 (Nm) |
| |
| Torque settings / Torque settings |
Timing chain guide rail |
17 (Nm) |
| |
| Torque settings / Torque settings |
Flexplate |
88 (Nm) |
| |
| Torque settings / Torque settings |
Ignition coil |
7 (Nm) |
| |
| Torque settings / Torque settings |
Coolant pump pulley |
10 (Nm) |
| |
| Torque settings / Torque settings |
Oil pump |
28 (Nm) |
| |
| Torque settings / Torque settings |
Oil pump gearwheel |
35 (Nm) |
| |
| Torque settings / Torque settings |
Front disc brakes |
|
| |
| Torque settings / Torque settings |
Front brake caliper guide bolt |
49 (Nm) |
| |
| Torque settings / Torque settings |
Front brake caliper carrier |
123 (Nm) |
| |
| Torque settings / Torque settings |
Brake hose to caliper |
16 (Nm) |
4-piston caliper | |
| Torque settings / Torque settings |
Rear disc brakes |
|
| |
| Torque settings / Torque settings |
Rear brake caliper guide pin |
43 (Nm) |
| |
| Torque settings / Torque settings |
Rear brake caliper carrier |
85 (Nm) |
| |
| Torque settings / Torque settings |
Brake hose to caliper |
16 (Nm) |
2-piston caliper | |
| Torque settings / Torque settings |
NISSAN, Automatic transmission, RE7R01A, Number of gears 7-speed |
|
| |
| Torque settings / Torque settings |
Automatic transmission drain plug |
34 (Nm) |
Renew the drain plug | |
| Torque settings / Torque settings |
Automatic transmission overflow plug |
13 (Nm) |
Renew the overflow plug | |
| Torque settings / Torque settings |
ETX13C |
|
| |
| Torque settings / Torque settings |
Transfer box filler plug |
35 (Nm) |
Renew the seal | |
| Torque settings / Torque settings |
Transfer box drain plug |
35 (Nm) |
Renew the seal | |
| Torque settings / Torque settings |
Front differential, F160A |
|
| |
| Torque settings / Torque settings |
Differential filler plug |
35 (Nm) |
Renew the seal | |
| Torque settings / Torque settings |
Differential drain plug |
35 (Nm) |
Renew the seal | |
| Torque settings / Torque settings |
Suspension |
|
| |
| Torque settings / Torque settings |
Note: Always renew stretch bolts and self-locking nuts |
|
| |
| Torque settings / Torque settings |
Front drive shaft to wheel bearing housing |
125 |
Renew the locking pin | |
| Torque settings / Torque settings |
Wheels and tyres |
|
| |
| Torque settings / Torque settings |
Wheel nuts |
108 (Nm) |
| |
| Torque settings / Torque settings |
Tyre pressure sensor |
8 (Nm) |
| |
| Torque settings / Torque settings |
Steering |
|
| |
| Torque settings / Torque settings |
Note: Always renew stretch bolts and self-locking nuts |
|
| |
| Torque settings / Torque settings |
Steering wheel |
35 (Nm) |
| |
| Torque settings / Torque settings |
Air conditioning |
|
| |
| Torque settings / Torque settings |
Air-conditioning compressor |
55 (Nm) |
| |
| Wheels and tyres / Tyre size |
Front tyre pressure |
2.3 (bar) |
| |
| Wheels and tyres / Tyre size |
Rear tyre pressure |
2.3 (bar) |
| |
| Wheels and tyres / Tyre size |
Wheel offset (ET) |
43 (mm) |
| |
| Wheels and tyres / Tyre size |
Rim size |
8.0Jx18 |
| |
| Wheels and tyres / Tyre size |
Front tyre pressure |
2.3 (bar) |
| |
| Wheels and tyres / Tyre size |
Rear tyre pressure |
2.3 (bar) |
| |
| Wheels and tyres / Tyre size |
Wheel offset (ET) |
43 (mm) |
| |
| Wheels and tyres / Tyre size |
Rim size |
9.0Jx20 |
| |
| Wheels and tyres / Tyre size |
Front tyre pressure |
2.3 (bar) |
| |
| Wheels and tyres / Tyre size |
Rear tyre pressure |
2.3 (bar) |
| |
| Wheels and tyres / Tyre size |
Wheel offset (ET) |
9.0Jx20 (mm) |
| |
| Wheels and tyres / Tyre size |
Rim size |
43 |
| |
| Engine (specifications) / Valve clearance |
Cold |
|
| |
| Engine (specifications) / Valve clearance |
Inlet |
0.26 - 0.34 (mm) |
| |
| Engine (specifications) / Valve clearance |
Exhaust |
0.29 - 0.37 (mm) |
| |
| Wheels and tyres / Wheels and tyres |
Wheels and tyres |
|
| |